25,000+ 2010 Mazda3s recalled over potential wiring harness fault

[armthehomeless]

The hotly-awaited Mazda3 is only now filtering into U.S. dealerships after hitting other markets, but there's already a snag – more than 25,000 units are being recalled.

According to the National Highway Traffic Safety Administration, the safety concern stems from a small tolerance issue: the clearance between the underside of the engine and the starter motor housing is apparently too narrow, which could result in a short circuit, leaving the car at risk of stalling and perhaps being unable to kick over again. As a result, NHTSA has issued a recall for the 25,400 new Mazda3s in the United States to have a simple clip installed and, if necessary, to have the problematic engine harness repaired.

PRESS RELEASE:

Vehicle Make / Model: Model Year(s):

MAZDA / MAZDA3 2010
Manufacturer: MAZDA MOTOR CORP Mfr's Report Date: APR 15, 2009

NHTSA CAMPAIGN ID Number: 09V126000
N/A

NHTSA Action Number: N/A

Component: ELECTRICAL SYSTEM

Potential Number of Units Affected: 25400

Summary:
MAZDA IS RECALLING 25,400 MY 2010 MAZDA3 VEHICLES. A CLEARANCE BETWEEN THE ENGINE HARNESS AND THE HOUSING OF STARTER MOTOR MAY BE INSUFFICIENT. DUE TO THIS, THE COVERING OF THE HARNESS MAY BE DAMAGED THROUGH VIBRATION DURING OPERATION POSSIBLY CAUSING A SHORT-CIRCUIT BETWEEN CERTAIN HARNESS WIRES AND THE STARTER HOUSING. A SHORT-CIRCUIT CAN RESULT IN ENGINE CONTROL MALFUNCTION AND/OR POOR SHIFT QUALITY.

Consequence:
THE MAIN FUSE MAY BLOW OUT CAUSING THE ENGINE TO STALL AND INABILITY OF RESTART, INCREASING THE RISK OF A CRASH.

Remedy:
DEALERS WILL HAVE THE ENGINE HARNESS INSPECT AND ADD A PROTECTOR CLIP ON THE AFFECTED SECTION OF THE HARNESS. IF NECESSARY, THE HARNESS WILL BE REPAIRED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON MAY 6, 2009. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500.

Notes:
MAZDA RECALL NO. 5409D. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Source: AutoBlog.

[tricache]

wicked!! Almost as bad as the new Corolla recall when the steering wheel would drop to the floor!

[Wardski]

Well, well, well.

This leads me to the point.... Not being biased but there have been no recalls on the Mitsu Lancer Evo X 08-09 models. None. Nada, Nothing! There was a brake issue with the low range VR and Outlander though (built before Dec 08 - affecting mostly 07 vehicles and not the current model)

For me its bye bye Mazda... Tollerance issues like that (those which should have been picked up during STRINGENT BALL BUSTING testing) are a clear indication where Mazda is heading.

I give it 2 months until there's another engine bolt recall. Anyone wanna bet with me?...

[armthehomeless]

When does the 2 months start??

[tricache]

I will bet you your new Evo Ward

[Wardski]

When does the 2 months start??

2 months start after the 2010 MPS is released in Aus

[armthehomeless]

Hmmm...yeah I'll do that bet.

What's the stakes??

[Wardski]

um... just let me think for a bit.... <buying plane ticket to another country to escape the bet>

[tricache]

come on Ward...you can so afford a case of beer to split between Rowan and I

Sorry Rowan, gotta get on this bet for sure!

[Nirvandan]

Cmon boys make it interesting

[Wardski]

Case of beerski it is.